One-step purification and characterization of two novel Thermotolerant β-1,4-glucosidases from a newly isolated strain of Fusarium chlamydosporum HML278

doi:10.21203/rs.3.rs-35610/v1

Download PDF

Original article

One-step purification and characterization of two novel Thermotolerant β-1,4-glucosidases from a newly isolated strain of Fusarium chlamydosporum HML278

https://doi.org/10.21203/rs.3.rs-35610/v1

This work is licensed under a CC BY 4.0 License

Journal Publication

published 08 Oct, 2020

Read the published version in AMB Express →

You are reading this older preprint version

Read the latest preprint version →

A newly screened cellulase-producing Fusarium chlamydosporum HML278 was cultivated under solid-state fermentation of sugarcane bagasse, and two new β-glucosides enzymes (BG FH1, BG FH2) from fermentation solution were recovered by modified non-denaturing active gel electrophoresis and gel filtration chromatography. SDS-PAGE analysis showed that the molecular weight of BG FH1and BG FH2 was 93 kDa and 52 kDa, respectively, and the enzyme activity was 5.6 U/mg and 11.5 U/mg, respectively. The optimal reaction temperature of the enzymes was 60 ℃, and the enzymes were stable under 70 ℃. The optimal pH of the purified enzymes was 6.0, and the enzymes were stable between pH 4–10. Km and Vmax values of 2.76 mg/mL, 20.6 U/mg for pNPG. Thin-layer chromatography and high-performance liquid chromatography analysis showed that cellobiose BG FH1and BG FH2 had hydrolysis activity and can hydrolyze cellobiose into glucose. In addition, both enzymes also exhibited transglycoside activity, which can use low molecular weight monosaccharides to synthesize cellobiose and cellotriose, and preferentially synthesize alcohol. In conclusion, our study demonstrated that F. chlamydosporum HML278 can produce heat-resistant β-glucosidase with both hydrolytic activity and transglycosidic activity, and has potential application value in bioethanol and papermaking industries.

Applied & Industrial Microbiology

Fusarium chlamydosporum HML278

β-glucosidase

purification

heat-resistant

transglycosidic activity

Two new β-glucosides enzymes of Fusarium chlamydosporum HML278 were purified.
The enzymes was were stable under 70 ℃ and exhibited transglycoside activity.
The enzymes have potential application value in bioethanol and papermaking industries.

Lignocellulose is a linear polysaccharide linked by D-glucose via β-(1,4)-glycosidic bonds, and is the most abundant renewable resource on earth (Zhang et al., 2010; Kovacs et al., 2009; Sánchez and Cardona, 2008). Lignocellulose can eventually be degraded into glucose under the synergy of the cellulase system: endoglucanase (EC 3.2.1.4) randomly acts on the non-crystalline region inside the cellulose molecule to produce glucose and short fiber oligosaccharides sugar; Exoglucanase (EC 3.2.1.91) hydrolyzes β-1,4-glycosidic bonds from outside to inside along the non-reducing end of cellulose to release cellooligosaccharides, cellobiose or glucose; β-glucosidase (EC 3.2 .1.21) hydrolyzes cellobiose or other soluble cellobiose and cellooligosaccharides into glucose (Gomes et al., 2018; Fan et al., 2016; Arantes and Saddler, 2010 ).

β-glucosidase plays an important role in the hydrolysis of cellulose. The intermediate products of cellulose hydrolysis, such as cellobiose, cellooligosaccharides, have a strong inhibitory activity on activity of exoglucanase and endoglucanase. β-glucosidase hydrolyzes cellobiose and cellooligosaccharides to produce glucose, reducing the inhibition of these intermediate products on exoglucanase and endoglucanase and improving the saccharification rate of cellulose enzymes, therby playing a key role in the degradation of cellulose(Gomes et al., 2018; Kamila et al., 2016; Chauve et al., 2010; Ikeda et al., 2006;Tanaka et al., 2006;Wen et al., 2005).

β-glucosidase is an important industrial enzyme that plays an important role in a variety of biotransformations. It has been used in many bioprocesses, including the processing of biofuels, paper industry, textile industry, waste, and food (Pei et al., 2012; Tian et al., 2010; Bayer et al., 2008; Han and Chen, 2008; Rubin 2008; Villena et al., 2007; Zaldivar et al., 2001).

Thermophilic fungi can produce a large amount of hydrolytic enzymes that hydrolyze cellulosic substances. The produced hydrolytic enzymes have good catalytic performance, high yield, and good stability, and are a promising industrial enzyme. (Zhang et al., 2014; Haven and Jørgensen, 2013; Prawitwong et al., 2013; Pei et al., 2012).

Screening of strains producing high β-glucosidase activity is very important for the comprehensive utilization of cellulose resources and their application in other fields (Miettinen-Oinonen et al., 2004;Saloheimo et al., 1997). Xylanase, endoglucanase, and other cellulose hydrolyzing enzymes from Fusarium sp. have strong cellulose degradation ability, and the synergistic effect of these enzymes can convert cellulose into ethanol（Gómez-Gómez et al., 2001;Kumar et al., 1991).

In our previous study, a heat-resistant cellulase-producing F. chlamydosporum strain HML278 was screened from the virgin forest samples in Guangxi, China. We for the first time identified that this strain can produce and secrete three major enzyme components of cellulase system, endoglucanase, microcrystalline cellulose, and β-glucosidase and xylanase (Qin et al., 2010). In this study, two new β-glucosidases with hydrolytic activity and transglycosidic activity from F. chlamydosporum HML278 were rapidly isolated and purified by using improved non-denaturing active gel electrophoresis combined with gel filtration chromatography. The optimal reaction temperature of the enzymes was 60 ℃, and the enzymes were stable below 70 ℃. The new identified enzymes may have great potential in industrial applications of bioethanol, papermaking, etc.

Production of cellullase by solid-state fermentation and enzymatic activity test

Strain: F. chlamydosporum HML278 used in this study was maintained on PDA medium at 4℃ in Guangxi Colleges Universities Key Laboratary of Exploitation and Utilization of Microbial and Botanical Resources.

Production of cellullase by solid-state fermentation: The screened cellulase-producing strain grown on PDA slant was washed off with 10 mL of physiological saline to make a spore liquid, and 10⁷ spores were transferred to the solid medium for second screening of cellulase. To make the solid medium for cellulase screen, 6 g bagasse, 4 g bran, and 30 mL Mandels nutrient solution (Kwon et al., 1994) were mixed in 500 ml erlenmeyer flask. The flask was flipped twice a day, and the strain was grown for 4 days at 30 °C. 200 mL of sterile ddH₂O was added to the culture, and was further leached at 40 °C in a constant temperature water bath for 1 hour. The culture was filtered with four layers of gauze, and centrifuged at 6000 r/min for 10 min. The supernatant containing crude enzymes was collected and stored at 4 °C until use (Qin et al., 2010).

Detection of β-Glucosidase enzyme activity: 0.02 M citric acid-sodium citrate buffer solution (pH 4.8) was used to prepare 1% salicin (Fluka Chemical Corp, USA) solution substrate. 0.05 mL of enzyme solution with appropriate concentration was mixed with 1mL of 1% salicin solution, and the reaction was carried out at 60 °C for 30 min. 3 mL of DNS reagent was added to stop the reaction. The reaction solution was boiled for 6 min, followed by cold water bath. The absorbance was measured at 540 nm. The amount of enzyme that produces 1 μmol of glucose per minute was defined as 1 unit of enzyme activity (U) (Shoemaker and Brown, 1978).

Rapid detection of β-glucosidase enzyme activity

Rapid detection plate of β-glucosidase enzyme activity (Kwon et al., 1994): ferric chloride 0.03%, aescin 0.1%, agar 1.5%.

Detection of soluble total protein

The protein concentration was measured at 595 nm according to the Bradford method (Bradford, 1976) by using a Bradford Protein Assay Kit (Beyotime Institute of Biotechnology, China) following the manufacture’s instruction.

Purification of β-glucosidase

All of purification steps were performed at 4 °C.

Active recovery of non-denaturing gel electrophoresis: The non-denaturing gel consisting of 8% separation gel and 4% stacking gel was run at 50 V constant voltage at 4 °C. After electrophoresis, the activity of β-glucosidase in the gel was detected by staining of gel with specific substrate (Kwon et al., 1994) containing 0.03% FeCl₃ and 0.1% aescin. After staining for 1 min at 30 °C, the gel was immediately rinsed with distilled water to stop the reaction. The active protein band with black precipitation was cut off, and grinded in a pre-cooled mortar. The sample was leached with citric acid-citrate buffer (20 mM, pH 4.8) at 4 °C for 12 h, and centrifuged at 4000 r/min for 20 min in a 5000 Da ultrafiltration tube for concentration and desalting.

The enzyme solution was further purified by HiPrep 16/60 Sephacryl S-200 h\High Resolution gel filtration chromatography column, using a BioLogic DuoFlow Pathfinder 80 purifier system (pressure 73 psi). The enzyme was eluted by using elution buffer containing 0.05 mol/L PBS and 0.15 mol/L NaCl (pH 7.2) at the flow rate of 1 mL/min. The enzyme activity of the purified protein was detected referring to the enzyme activity rapid detection plate of β-glucosidase, and the protein purity was detected by using SDS-PAGE.

SDS– polyacrylamide gel electrophoresis（SDS–PAGE）

12% resolving gel was used in SDS-polyacrylamide gel electrophoresis, and the gel was stained with Coomassie Brilliant Blue R250. The molecular weight of purified proteins was assessed by comparing the relative mobility of purified protein with low molecular weight standard protein (Laemmli, 1970).

Zymogram analysis of purified enzyme

The collected extracellular enzyme solution of HML278 was subjected to non-denaturing protein gel electrophoresis with pH 8.3 electrophoresis buffer at 4 ℃ by using 50 V constant voltage. The separation gel and stacking gel was made by 8% acrylamide and 4% acrylamide, respectively. After the electrophoresis, the acrylamide separation gel was cut and partly stained with silver, and the other part was stained with specific substrates of different cellulases.

To analyze the activity of β-glucosidase from cut gel, the gel was active stained with staining solution containing 0.1% escin (Sigma) and 0.03% ferric chloride (Sigma) for 5 minutes at 30 ℃. The protein with β-glucosidase activity will catalyze the substrate to produce a yellow-black product (Kwon et al., 1994).

Analysis on the hydrolysis activity of purified β-glucosidase

Experiments for HML0366 β-glucosidase enzyme hydrolysis activity and transglycoside-mediated synthesis of gentiobiose.

β-glucosidase hydrolysis assay: 10 mL of 1℅ (m/v) cellobiose dissolved in citrate buffer (50 mM, pH 4.8) was used as a substrate, and 2 mL of enzyme solution was added to react at 30 °C for 30 min.

High performance liquid chromatography (HPLC) analysis of sugar components: The system utilized a refractive index detector and Hanbang amino column (250 mm × 4.6 mm, 5 μm, (Hanbon Sci. & Tech. Lichospher NH2, China). 40 ℃; mobile phase: acetonitrile/Water (4: 1, v/v); flow rate: 1 mL/min; injection volume: 5 μL.

TLC method for detecting sugar components (Jo et al., 2003): Silica thin-layer chromatography detection was utilized. Expanding agent: n-butanol: ethyl acetate: ammonia: water = 6: 3: 3: 1 (v/v). Developer: A: 1g aniline + 25 mL acetone, B: 1 mL dianiline + 25 mL acetone. After mixing A and B, 5 mL 85% phosphoric acid was added and mixed well. After the chromatography, the plate was blown dry and color developer was sprayed, and dried at 120 °C for 10 minutes to develop color.

Cellobiose was dissolved in 20 mM citrate buffer (pH 4.8), and enzyme solution was added at 100: 1 (v/v), and reacted at 30 °C for 3 h. The product was detected by thin-layer chromatography (Jo et al., 2003; Qin et al., 2011).

Detection and identification of proteins by tandem time-of-flight mass spectrometry

Identification of purified enzymes by tandem time-of-flight mass spectrometry: After SDS-PAGE, the β-glucosidase band was cut out, and the fingerprints of peptide fragments were obtained after scanning analysis by time-of-flight mass spectrometry (4800 Proteomics Analyzer, Applied Biosystems, USA), and the data was analyzed by using the Mascot software to query and identify purified enzymes on the SWISS-PROT database (Scheibner et al., 2008; Lee et al., 2007).

Enzymatic properties of purified enzyme

The effect of temperature on the enzyme activity and stability of β-glucosidase

The definition of relative enzyme activity: the highest enzyme activity under a certain condition of the experimental project was set to 100℅, and the ratio of enzyme activity under other conditions to the highest enzyme activity was defined as relative enzyme activity.

The enzyme activity was measured under the conditions of 30℃-90℃ in 50 mM acetate buffer to determine the optimal temperature of endoglucanase and β-glucosidase.

To determine the effect of temperature on the stability of β-glucosidase, the enzyme was further incubated in a water bath at temperatures between 40 ℃ and 90 ℃ with a gradient of 5 ℃. The enzymes were incubated at each temperature for 60 min, and the residual enzyme activity was then measured at 60 ℃.

The impact of pH for enzyme activity and stability of β-glucosidase

To determine the effect of pH on enzyme activity of β-glucosidase, the following four solutions with a concentration of 50 mM were used: disodium hydrogen phosphate-citric acid buffer, pH 2.6-7.5; Tris-HCl buffer, pH7.5-pH 9.0; glycine-NaOH buffer, pH 9.0-11.0.

Under the temperature condition where the enzyme is stable, the enzyme was mixed with the buffer with a pH value ranging between 3.0 to 9.0, and the relative enzyme activities and the optimal pH value of endoglucanase and β-glucosidase were determined.

The enzyme was further stored in a solution with a pH value between 3.0-11.0. After being left at 4 °C for 24 hours, it was kept at 30 °C for 3 hours. The relative enzyme activities of endoglucanase and β-glucosidase were determined at the optimum pH and temperature.

Effect of metal ions on β-glucosidase enzyme activity

Different metal ions were added to the purified enzyme solution with a final concentration of 2 mM, and the enzyme activity was tested. The enzyme activity was calculated according to the average value of data from three parallel experiments.

Kinetics analysis of the purified β-glucosidase

To determine the kinetic parameters of the enzymatic reaction of β-glucosidase, pNPG was used as the substrate and the reaction was performed under pH 4.8 at 30 ℃. The initial reaction rate was calculated, and the Km value and Vmax of the purified β-glucosidase was calculated by using double reciprocal plotting method (Lineweaver-Burk plot (Lineweaver and Burk, 1934).

Purification and characterization of β-glucosidase from F. chlamydosporum HML278 fermented solution

It was shown that the enzyme activity of β-glucosidase reached a maximum of 115.2 U/g after 4 days of solid bagasse culture of F. chlamydosporium HML278 enzyme activity. To purify the enzymes from fermented solution of F. chlamydosporium HML278, an anion exchange column was initially utilized, but the separation effect was not good, and there was no obvious protein peak, it was speculated that the isoelectric point may be too high. A total of 115.2 U (20mL) of crude enzyme solution was further subjected to non-denaturing gel electrophoresis without adding a comb in order to increase the sample load (Figure 1). The active gel was recovered, and subjected to gel filtration chromatography. The enzyme BG FH1was obtained after about 48 min, and BG FH2 was obtained about 64 min after running (Figure 2). SDS-PAGE analysis showed that the molecular weights of BG FH1and BG FH2 were 93 kDa and 52 kDa, respectively (Figure 3), and the recovery rates of purification were 4.0% and 20.0%, respectively. The fold-purification of BG FH1and BG FH2 was 14.0 and 28.8 (table 1), respectively，and the enzyme activity for each enzy was 5.6 U/mg and 11.5 U/mg, respectively. The zymography analysis of non-denaturing electrophoresis showed that the strain produced two different β-glucosidases, and these two β-glucosidases are a single subunit enzyme (Figure 4).

In addition, some other peptide sequences were detected by tandem time-of-flight mass spectrometry, but there was no any enzyme information in the protein database, thus these protein sequences were not identified.

The hydrolysis activity of BG FH1 and BG FH2

The thin-layer chromatography experiment showed that both BG HG1 and BG HG2 have hydrolytic activity, and can hydrolyze cellobiose to generate glucose. In addition, the enzymes also showed transglycoside activity and can synthesize cellotriose and cellotetraose using low molecular weight monosaccharides (Figure 5).

High performance liquid chromatography analysis showed that BG FH1 hydrolyzed cellobiose (retention time, 10.72 min) to obtain glucose (retention time 7.36 min), and glucose could be further used as a substrate to synthesize cellotriose (retention time 12.46 min) (Figure 6). BG FH1 transglycoside activity is stronger than other strains of the same genus (Kaya et al., 2008; Seidle et al., 2006; Seidle and Huber, 2005).

In addition, high-performance liquid chromatography analysis also showed that BG FH1can hydrolyze cellobiose into glucose and also synthesize cellotriose (Figure 6), indicating that BG FH1has transglycoside activity.

The properities of β-glucosidase isolated from F. chlamydosporum HML278

Optimum temperature and thermal stability of β-glucosidase

The experimental results showed that the optimum temperature of β-glucosidases BG FH1 and BG FH2 from F. chlamydosporium HML278 was 60 ℃ at pH 5.0. The β-glucosidase exhibited good stability at temperature below 70 ℃, and the the enzyme can maintain 75% of the enzyme activity when incubated at 70 ℃ for 1 hour (Figure 7). Enzymes that are stable at temperatures above 60 °C are defined as heat-resistant enzymes, and these enzymes play an important role in the production of alcohol by enzymatic saccharification and fermentation of biomass materials (Alani et al., 2008). It has been shown that Fusarium species can produce heat-resistant cellulase (Quarantin et al., 2019; Christakopoulos et al., 1995; Kumar et al., 1991; Christakopoulos et al., 1989; Matsumoto et al., 1974; Wood, 1969;). Our study for the first time reported that F. chlamydosporium can produce heat-resistant cellulase (Qin et al., 2010).

Chan et al. purified β-glucosidase DT-Bgl and showed that the enzyme exhibited the maxium activity at 70 °C. After hydrolysis of substrate into glucose, it can be further fermented to produce ethanol (Chan et al., 2016). Liew et al. purified a new β-glucosidase BglD5 (GH1) from Jeotgalibacillus malaysiensis, and BglD5 was stable at temperature below 65℃, which promoted the cellulase hydrolysis (Liew et al., 2018 ). Kumar found that endoglucanase and β-glucosidase did not lose their enzymatic activity within 60 minutes at 80 °C. These high-temperature enzymes are suitable for application in cellulosic ethanol production (Kumar et al., 1991). Tiwari et al. found that β-glucosidase RA10 from Bacillus subtilis was stable at a temperature of 80 ℃. The heat-stable β-glucosidase enhanced saccharification efficiency and thus released much higher level of glucose than previous reports. This enzyme can enhance the efficiency of hydrolysis and hydrolyze the substance of cellulose into fermentable sugar (Tiwari et al., 2017). Xia et al. found that the cellulase with good thermal stability (stable at 60 ℃) can significantly improve the saccharification efficiency of cellulose hydrolysis (Xia et al., 2016).

Thermophilic fungi can produce heat-stable enzymes It is of note that cellulose swells at high temperature, which makes it easier to break down. Thus, high temperature can promote the penetration of enzymes into materials and result in a better degradation. The screening of thermophilic fungi and the application of heat-resistant enzymes are important research directions for comprehensive applications of cellulose (Moretti et al.， 2012; de Cassia Pereira et al.，2015).

The optium pH and stability of purified β-glucosidase at different pH conditions

The β-glucosidases produced by F. chlamydosporum HML278 were relatively stable in the pH ranging from 4.0 to 10.0, and showed maximum activity pH 6.0 (Figure 8). Christakopoulos et al. screened a strain of Fusarium oxysporum and which had a optimum pH of 4.5 (Christakopoulos et al.，1995). Matsumoto et al. screened a Fusarium moniliforme strain and the β-glucosidase produced by this strain was stable at pH between 4.0 to 11.0, whereas the enzyme with a wide pH tolerance range usually has broader applications (Matsumoto et al.，1974). Since F. chlamydosporum has a wode pH tolerance range, it may have greater application potential (Christakopoulos et al.，1995;Christakopoulos et al., 1989; Matsumoto et al.，1974;Wood，1969).

Effect of metal ions on the β-glucosidase purified from F. chlamydosporum HML278

Metal ions are often used as activators or inhibitors in the catalytic reaction of enzymes (Grasso et al., 2012). Therefore, adding appropriate metal ions to the enzyme reaction system can improve the catalytic efficiency of the enzyme.

It was shown that Ag²⁺, Co²^＋, Cu²⁺, Zn²⁺, and Hg²⁺ strongly inhibited the β-glucosidase purified from F. chlamydosporum HML278. In contrast, Mn²⁺, Ca²⁺, Mg²⁺, and Fe³⁺significantly activated enzyme, whereas Zn²⁺ and Ni⁺ had no obvious effect on the enzyme activity (Table 2).

It was observed that all divalent metal ions had different effect on the enzyme activity. The bivalent ions Hg²⁺ and Co²⁺ completely inhibited enzyme activity. Hg²⁺ can interact with cysteine residues in sulfhydryl bonds (Stricks and Kolthoff, 1953). It reacts with cysteine residues, especially in -SH group, and can change the tertiary structure of the protein (Lee et al., 2018). It was speculated that the active site may contain sulfhydryl groups, and these sulfhydryl groups participate in the catalysis and are essential for maintaining the structure of the enzyme (Joo et al., 2009).

The divalent cobalt ion forms a complex with various amino acids, and binding of the cobalt ion to active site of the enzyme is irreversible, completely inhibiting the activity of the enzyme. Other ions, such as Mg²⁺, Mn²⁺, Ca²⁺, Na⁺, Cu²⁺, and Fe³⁺ also tend to form metal complexes with proteins, which ultimately affect enzyme activity by changing protein structure (Shrivastava et al., 2017).

Feng reported that Ca²⁺ increased β-glucosidase Bgl3A activity by 20% (Feng et al., 2015). Xie reported that Ca²⁺at a concentration of 5 mM increased β-glucosidase activity by 58% (Xie et al., 2015). It has been reported that Ca2+ and Mg2+ can bind to enzymes to form a stable conformation and improve the catalytic effect (Oyekola et al.，2007).

Kinetic experiment of β-glucosidase purified from F. chlamydosporum HML278

By using pNPG as a substrate, it was shown that the Km and Vmax values of β-glucosidase were 2.76 mg/mL and 20.6 U/mg, respectively.

This study reported for the first time that F. chlamydosporum HML278 can utilize sugarcane bagasse as carbon source for solid-state fermentation to produce high-temperature-resistant β-glucosidase. By employing non-denaturing gel recovery and gel filtration chromatography, two β-glucosidase BG FH1 and BG FH2 were purified, with molecular weights of 93 kDa and 52 kDa, respectively. Purified BG FH1 and BG FH2 were β-glucosidase enzymes with high transglycosidic activity. Thin-layer chromatography and high-performance liquid chromatography analysis showed that BG FH1and BG FH2 had hydrolytic activity and hydrolyzed cellobiose into glucose. At meantime, the enzymes had transglycosidic activity and can synthesize cellobiose and cellotriose using low molecular weight monosaccharides.

The optimum temperature for purified BG FH1 and BG FH2 from F. chlamydosporum HML278 was 60 ℃, and the enzymes were stable below 70 ℃. The enzymes had highest activity at pH 6.0, and were stable in the pH ranging from pH 4.0 to pH 10.0. Ag²⁺, Co²⁺, Cu²⁺, Zn²⁺, and Hg²⁺ had strong inhibitory effect on the purified enzymes, while Mn²⁺, Ca²⁺, Mg²⁺, and Fe³⁺ had obvious activation effect on the enzymes, and Zn²⁺ and Ni⁺ had no obvious effects on enzymes. In addition, some peptide sequences were also identified by tandem time-of-flight mass spectrometry, but there was no relative information on these peptides in the protein database.

β-glucosidase is a key enzyme that is involved in cellulolytic enzyme-mediated hydrolysis. The presence ofsufficient β-glucosidases can also improve the saccharification efficiency of cellulose (Teugjas and Väljamäe, 2013; Prawitwong et al., 2013; Ng et al., 2011).

Heat-stable enzymes have obvious advantages as catalysts. Because high temperature can promote the enzyme penetration and cell wall destruction during the process (Kwon et al., 1994), the hydrolysis effect is usually better. Thermophilic fungi are now considered to be a promising source for producing thermostable cellulase that used for cellulose degradation, and can increase the saccharification rate (de Cassia Pereira et al., 2015).

By using nuclear magnetic resonance analysis, Makropoulou et al. found that β-glucosidase from Fusarium oxysporum has transglycosidic activity. It can catalyze a variety of disaccharides to generate β-D-glucose through transglycosidation. Fusarium oxysporum can directly hydrolyze cellulose and synthesize monoalcohol ethanol, glycol glycol, and triol glycerol after saccharification. Because β-glucosidase has transglycosidic activity, monoethanol alcohol is preferentially synthesized (Makropoulou et al., 1998). The cellulase produced by Fusarium spp. is heat-resistant. It has been reported that Fusarium spp. can also produce enzymes involved in alcohol production, which can saccharify cellulose materials while convert the five- or six-carbon sugars to alcohol (Brunner and Lichtenauer, 2007; Gómez-Gómez et al., 2001; Maheshwari et al., 2000; Royer and Moyer, 1995; Kumar et al., 1991; Singh and Kumar, 1991; Vaidy and Seeta, 1984; Woo and McCrae, 1977; Sampathnarayanan and Shanmugasundaram, 1970). In conclusion, we characterized two β-glucosidases with both hydrolytic and transglycoside activities from F. chlamydosporum HML278 fermentation, and these identified enzymes have great potential in industrial application, such as bioethanol, papermaking, feed, food, textile, detergent, and pharmaceutical industries (Xie et al., 2015; Kim et al., 2011; Alani et al., 2008; Maheshwari et al., 2000).

Fusarium chlamydosporum HML278 is a High Cellulase Producing Strain selected by us.

Published a paper in world J Microbiol biotechnology in 2010: Isolation and characterization of a thermostable cellulase-producing Fusarium chlamydosporum. https://doi.org/10.1007/s11274-010-0383-x.

Acknowledgements

The authors would like to acknowledge Guangxi Colleges Universities Key Laboratory of Exploitation and Utilization of Microbial and Botanical Resources for supporting our study.

Funding information

This study was supported by National Natural Science Foundation of China (No. 31660017).

Availability of data and materials

All data generated or analysed during this study are included in this published article.

Ethics approval and consent to participate

This work did not involve the direct study of humans. All applicable international, national, and/or institutional guidelines for the care and use of animals were followed and all.

Consent for publication

The authors confirm that the work described has not been published before, that it is not under consideration for publication elsewhere, that its publication has been approved by all co-authors. The authors agree to publication in the Journal of AMB Express.

Author Contribution Statement

YLQ and HYH conceived and designed the research. YLQ wrote the paper. YLQ , QQL and YF conducted the experiments. YLQ and FFL analyzed data. All authors read and approved the manuscript.

Conflict of interest

The authors declare that they have no conflict of interest.

Ethical approval

This article does not contain any studies with human participants or animals performed by any of the authors.

Author details

¹ College of Chemistry and Biological Engineering, Hechi University, Yizhou 546300, China. ² Guangxi Colleges Universities Key Laboratory of Exploitation and Utilization of Microbial and Botanical Resources, Yizhou 546300, China.

Alani F, Anderson WA, Moo-Young M (2008) New isolate of Streptomyces sp. with novel thermoalkalotolerant cellulases. Biotechnol Lett 30:123–126. https://doi.org/10.1007/s10529-007-9500-9

Arantes V, Saddler JN (2010) Access to cellulose limits the efficiency of enzymatic hydrolysis: the role of amorphogenesis. Biotechnol Biofuels 3, 4. https://doi.org/10.1186/1754-6834-3-4

Bayer EA, Lamed R, White BA, Flint HJ (2008) From cellulosome to cellulosomics. Chem Rec 8:364–377. https://doi.org/doi:10.1002/tcr.20160

Bradford MM (1976) A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. Anal Biochem 7:248-254. http://doi.org/10.1006/abio.1976.9999

Brunner K, Lichtenauer AM, Kratochwill K, Delic M, Mach RL (2007) Xyr1 regulates xylanase but not cellulase formation in the head blight fungus Fusarium graminearum. Curr Genet 52:213-220. https://doi.org/10.1007/s00294-007-0154-x

Chan CS, Sin LL, Chan KG, Shamsir MS, Manan FA, Sani RK, Goh KM (2016) Characterization of a glucose‑tolerant β-glucosidase from Anoxybacillus sp. DT3‑1. Biotechnol Biofuels 9: 174. https://doi.org/10.1186/s13068-016-0587-x. eCollection 2016

Chauve M, Mathis H, Huc D, Casanave D, Monot F, Lopes Ferreira N (2010) Comparative kinetic analysis of two fungal β-glucosidases. Biotechnol Biofuels 3: 3.https://doi.org/10.1186/1754-6834-3-3

Christakopoulos P, Kekos D, Macris BJ, Claeyssens M, Bhat MK (1995) Purification and characterization of a less randomly acting endo-1,4-beta-D-glucanase from the culture filtrates of Fusarium oxysporum. Arch Biochem Biophys 316(1):428-433. https://doi.org/10.1006/abbi.1995.1057

Christakopoulos P, Macris BJ, Kekos D (1989) Direct fermentation of cellulose to ethanol by Fusarium oxysporum. Enzyme Microb Technol 11(4):236-239. https://doi.org/10.1016/0141-0229(89)90098-7

de Cassia Pereira J, Paganini Marques N, Rodrigues A, Brito de Oliveira T, Boscolo M, da Silva R, Gomes E, Bocchini Martins DA (2015) Thermophilic fungi as new sources for production of cellulases and xylanases with potential use in sugarcane bagasse saccharification. J Appl Microbiol 118:928–939. https://doi.org/10.1111/jam.12757

Fan LH, Zhang ZJ, Mei S, Lu YY, Li M, Wang ZY, Yang JG, Yang ST, Tan TW (2016) Engineering yeast with bifunctional minicellulosome and cellodextrin pathway for coutilization of cellulose-mixed sugars. Biotechnol Biofuels 9:137. https://doi.org/ 10.1186/s13068-016-0554-6.eCollection 2016

Feng T, Liu H, Xu Q, Sun J, Shi H (2015) Identification and characterization of two endogenous β-glucosidases from the termite Coptotermes formosanus. Appl Biochem Biotechnol 176(7):2039–2052. https://doi.org/10.1007/s12010-015- 1699-7

Gomes DG, Serna-Loaiza S, Cardona CA, Gama M, Domingues L (2018) Insights into the economic viability of cellulases recycling on bioethanol production from recycled paper sludge. Bioresour Technol 267:347-355. https://doi.org/10.1016/j.biortech.2018.07.056

Gómez-Gómez E, Isabel M, Roncero G, Di Pietro A, Hera C (2001) Molecular characterization of a novel endo-beta-1,4-xylanase gene from the vascular wilt fungus Fusarium oxysporum. Curr Genet 40(4): 268-275. https://doi.org/10.1007/s00294-001-0260-0

Grasso G, Salomone F, Tundo GR, Pappalardo G, Ciaccio C, Spoto G, Pietropaolo A, Coletta M (2012) Metal ions affect insulin-degrading enzyme activity. J Inorg Biochem 117:351–358.https://doi.org/10.1016/j.jinorgbio.2012.06.010

Han Y, Chen H (2008) Characterization of β-glucosidase from corn stover and its application in simultaneous saccharification and fermentation. Bioresour Technol 99:6081–6087. https://doi.org/10.1016/j.biortech.2007.12.050

Haven MO, Jørgensen H (2013) Adsorption of β-glucosidases in two commercial preparations onto pretreated biomass and lignin. Biotechnol Biofuels 6:165. https://doi.org/10.1186/1754-6834-6-165

Ikeda Y, Park EY, Okida N (2006) Bioconversion of waste office paper to gluconic acid in a turbine blade reactor by the filamentous fungus Aspergillus niger. Bioresour Technol 97:1030–1035. https://doi.org/10.1016/j.biortech.2005.04.040

Joo AR, Jeya M, Lee KM, Sim WI, Kim JS, Kim IW, Kim YS, Oh DK, Gunasekaran P, Lee JK (2009) Purification and characterization of a β-1, 4-glucosidase from a newly isolated strain of Fomitopsis pinicola. Appl Microbiol Biotechnol 83:285–294. https://doi.org/10.1007/s00253-009-1861-7

Jo YY, Jo KJ, Jin YL, Kim KY, Shim JH, Kim YW, Park RD (2003) Characterization and kinetics of 45 kDa chitosanase from Bacillus sp. P16. Biosci Biotechnol Biochem 67:1875-1882. https://doi.org/10.1271/bbb.67.1875

Kamila PB, Piotr P, Halina K, Kazimierz P, Marta K, Marcin D (2016) Evaluation of pine kraft cellulosic pulps and fines from papermaking as potential feedstocks for biofuel production. Cellulose 23:649–659. https://doi.org/10.1007/s10570-015-0808-7

Kaya M, Ito J, Kotaka A, Matsumura K, Bando H, Sahara H, Ogino C, Shibasaki S, Kuroda K, Ueda M, Kondo A, Hata Y (2008) Isoflavone aglycones production from isoflavone glycosides by display of beta-glucosidase from Aspergillus oryzae on yeast cell surface. Appl Microbiol Biotechnol 79(1): 51-60. https://doi.org/10.1007/s00253-008-1393-6

Kim YS, Yeom SJ, Oh DK (2011) Characterization of a GH3 family beta-glucosidase from Dictyoglomus turgidum and its application to the hydrolysis of isoflavone glycosides in spent coffee grounds. J Agric Food Chem 59(21):11812–11818. https://doi.org/10.1021/jf2025192

Kovacs K, Macrelli S, Szakacs G, Zacchi G (2009) Enzymatic hydrolysis of steam-pretreated lignocellulosic materials with Trichoderma atroviride enzymes produced in-house. Biotechnol Biofuels 2:14. https://doi.org/10.1186/1754-6834-2-14

Kumar PKR, Singh A, Schuegerl K (1991) Fed-batch culture for the direct conversion of cellulosic substrates to acetic acid/ethanol by Fusarium oxysporum. Process Biochemistry 26(4):209-216. https://doi.org/10.1016/0032-9592(91)85002-6

Kwon KS, Lee J, Kang HG, Hah YC (1994) Detection of β-Glucosidase Activity Polyacrylamide Gels with Esculin as Substrate. Appl Environ Microbiol 12: 4584-4586.

Laemmli UK (1970) Cleavage of structural proteins during the assembly of the head of bacteriophage T4. Nature 227:680-685. https://doi.org/10.1038/227680a0

Lee C, O'Neill MA, Tsumuraya Y, Darvill AG, Ye ZH (2007) The irregular xylem9 mutant is deficient in xylan xylosyltransferase activity. Plant Cell Physiol 48(11):1624-1134. https://doi.org/10.1093/pcp/pcm135

Lee HJ, Lee YS, Choi YL(2018) Cloning, purification, and characterization of an organic solvent-tolerant chitinase, MtCh509, from Microbulbifer thermotolerans DAU221. Biotechnol Biofuels 11:303. https://doi.org/10.1186/s13068-018-1299-1

Liew KJ, Lim L, Woo HY, Chan KG, Shamsir MS, Goh KM (2018) Purification and characterization of a novel GH1 beta-glucosidase from Jeotgalibacillus malaysiensis. Int J Biol Macromol 115:1094–1102. https://doi.org/10.1016/j.ijbiomac.2018.04.156

Lineweaver H, Burk D (1934) The determination of enzyme dissociation constants. J Am Chem Soc 56:658-666. https://doi.org/10.1021/ja01318a036

Maheshwari R, Bharadwaj G, Bhat MK (2000) Thermophilic Fungi: Their Physiology and Enzymes . Microbiol Mol Biol Rev 64:461–488. https://doi.org/10.1128/mmbr.64.3.461-488.2000

Makropoulou M, Christakopoulos P, Tsitsimpikou C, Kekos D, Kolisis FN, Macris BJ (1998) Factors affecting the specificity of beta-glucosidase from Fusarium oxysporum in enzymatic synthesis of alkyl-beta-D-glucosides. Int J Biol Macromol 22(2):97-101. https://doi.org/10.1016/s0141-8130(97)00092-5

Matsumoto K, Endo Y, Tamiya N, Kano M, Miyauchi K (1974) Studies on cellulase produced by the phytopathogens. Purification and enzymatic properties of cellulase of Fusarium moniliforme. J Biochem 76:563–572. https://doi.org/10.1093/oxfordjournals.jbchem.a130600

Miettinen-Oinonen A, Londesborough J, Joutsjoki V, Lantto R, Vehmaanperä J, Ltd. Biotec P (2004) Three cellulases from Melanocarpus albomyces for textile treatment at neutral pH. Enzyme Microb Technol 34:332-341. https://doi.org/10.1016/j.enzmictec.2003.11.011

Moretti MM, Bocchini-Martins DA, Silva RD, Rodrigues A, Sette LD, Gomes E (2012) Selection of Thermophilic and Thermotolerant Fungi for the Production of Cellulases and Xylanases Under Solid-State Fermentation. Braz J Microbiol 43(3):1062-1071. https://doi.org/10.1590/S1517-838220120003000032

Ng IS, Tsai SW, Ju YM, Yu SM, Ho TH (2011) Dynamic synergistic effect on Trichoderma reesei cellulases by novel β-glucosidases from Taiwanese fungi. Bioresour Technol 102, 6073–6081. https://doi.org/10.1016/j.biortech.2010.12.110

Oyekola OO, Ngesi N, Whiteley CG (2007) Isolation, purification and characterisation of an endoglucanase and β-glucosidase from an anaerobic sulphidogenic bioreactor. Enzyme Microb Technol 40:637–644. https://doi.org/10.1016/j.enzmictec.2006.05.020

Pei J, Pang Q, Zhao L, Fan S, Shi H (2012) Thermoanaerobacterium thermosaccharolyticum β-glucosidase: a glucose-tolerant enzyme with high specific activity for cellobiose. Biotechnol Biofuels 5:31. https://doi.org/10.1186/1754-6834-5-31

Prawitwong P, Waeonukul R, Tachaapaikoon C, Pason P, Ratanakhanokchai K, Deng L, Sermsathanaswadi J, Septiningrum K, Mori Y, Kosugi A (2013) Direct glucose production from lignocellulose using Clostridium thermocellum cultures supplemented with a thermostable β-glucosidase. Biotechnol Biofuels 6:184. https://doi.org/10.1186/1754-6834-6-184

Qin YL, He HY, Li N, Ling M, Liang ZQ (2010) Isolation of a thermostable cellulase-producing Fusarium chlamydosporum and characterization of the cellulolytic enzymes. World J Microb Biot 26(11):1991-1997. https://doi.org/10.1007/s11274-010-0383-x

Qin YL, Zhang YK, He HY, Zhu J, Chen GG, Li W, Liang ZQ (2011) Screening and Identification of a Fungal β-Glucosidase and the Enzymatic Synthesis of Gentiooligosaccharide. Appl Biochem Biotechnol 163:1012–1019. https://doi.org/10.1007/s12010-010-9105-y

Quarantin A, Castiglioni C, Schäfer W, Favaron F, Sella L (2019) The Fusarium Graminearum Cerato-Platanins Loosen Cellulose Substrates Enhancing Fungal Cellulase Activity as Expansin-Like Proteins. Plant Physiol Biochem 139:229-238. https://doi.org/10.1016/j.plaphy.2019.03.025

Royer JC, Moyer DL, Reiwitch SG, Madden MS, Jensen EB, Brown SH, Yonker CC, Johnston JA, Golightly EJ, Yoder WT, Shuster JR (1995) Fusarium graminearum A 3/5 as a novel host for heterologous protein production. Biotech 13(13):1479-1483. https:doi.org/10.1038/nbt1295-1479

Rubin EM (2008) Genomics of cellulosic biofuels. Nature 454:841–845. https://doi.org/10.1038/nature07190

Saloheimo M, Nakari-Setälä T, Tenkanen M, Penttilä M (1997) cDNA cloning of a Trichoderma reesei cellulase and demonstration of endoglucanase activity by expression in yeast. Eur J Biochem 24:584-591. https://doi.org/10.1111/j.1432-1033.1997.00584.x

Sampathnarayanan A, Shanmugasundaram ER (1970) Studies on cellulase of the cotton wilt pathogen Fusarium vasinfectum Atk. Mycopathol Mycol Appl 41(3):223-232. https://doi.org/10.1007/BF02051100

Sánchez OJ, Cardona CA (2008) Trends in biotechnological production of fuel ethanol from different feedstocks. Bioresour Technol 99:5270–5295. https://doi.org/10.1016/ j.biortech.2007.11.013

Scheibner M, Hülsdau B, Zelena K, Nimtz M, de Boer L, Berger RG, Zorn H (2008) Novel peroxidases of Marasmius scorodonius degrade beta-carotene. Appl Microbiol Biotechnol 77:1241-1250. https://doi.org/10.1007/s00253-007-1261-9

Seidle HF, Allison SJ, George E, Reuben E, Huber RE (2006) Trp-49 of the family 3 beta-glucosidase from Aspergillus niger is important for its transglucosidic activity: creation of novel beta-glucosidases with low transglucosidic efficiencies. Arch Biochem Biophys 455: 110-118. https://doi.org/10.1016/j.abb.2006.09.016

Seidle HF, Huber RE (2005) Transglucosidic reactions of the Aspergillus niger family 3 beta-glucosidase: qualitative and quantitative analyses and evidence that the transglucosidic rate is independent of pH. Arch Biochem Biophys 436(2):254-264. https://doi.org/10.1016/ j.abb.2005.02.017

Shoemaker SP, Brown RD (1978) Characterization of endo-1,4-beta-D-glucanases purified from Trichoderma virid . Biochim Biophys Acta 523:147-161. https://doi.org/10.1016/0005-2744(78)90017-7

Shrivastava LK, Kumar A, Senger SS, Mishra VN, Panda A (2017) Influence of zypmite on productcivity and nutrient uptake of chickpea (Cicer arietinum ) crop under rainfed condition Chhattisgarh plain region. Legume Res 41:95–101. https://doi.org/10.18805/LR-3586

Singh A, Kumar PK (1991) Fusarium oxysporum: status in bioethanol production. Crit Rev Biotechnol 11(2):129-147. https://doi.org/10.3109/07388559109040619

Stricks W, Kolthoff IM (1953) Reactions between mercuric mercury and cysteine and glutathione. apparent dissociation constants, heats and entropies of formation of various forms of mercuric mercapto-cysteine and -glutathione, J. Am. Chem. Soc 75: 5673–5681. https://doi.org/ 10.1021/ja01118a060

Tanaka T, Hoshina M, Tanabe S, Sakai K, Ohtsubo S, Taniguchi M (2006) Production of D-lactic acid from defatted rice bran by simultaneous saccharification and fermentation. Bioresour Technol 97: 211–217. https://doi.org/10.1016/j.biortech.2005.02.025

Teugjas H, Väljamäe P (2013) Selecting β-glucosidases to support cellulases in cellulose saccharification. Biotechnol Biofuels 6:105. https://doi.org/10.1186/1754-6834-6-105

Tian S, Luo XL, Yang XS, Zhu JY (2010) Robust cellulosic ethanol produc‑tion from SPORL‑pretreated lodgepole pine using an adapted strain Saccharomyces cerevisiae without detoxification. Bioresour Technol 101: 8678–85. https://doi.org/10.1016/ j.biortech.2010.06.069

Tiwari R, Singh PK, Singh S, Nain, Pawan KS, Nain, Shukla P (2017) Bioprospecting of novel thermostable β-glucosidase from Bacillus subtilis RA10 and its application in biomass hydrolysis. Biotechnol Biofuels 10:246. https://doi.org/10.1186/s13068-017-0932-8

Wen Z, Liao W, Chen S (2005) Production of cellulase by Trichoderma reesei from dairy manure. Bioresour Technol 96: 491–499. https://doi.org/10.1016/j.biortech.2004.05.021

Wood TM (1969) The cellulase of Fusarium solani. Resolution of the enzyme complex. Biochem J 115(3):457–464. https://doi.org/10.1042/bj1150457

Wood TM, McCrae SI (1977) Cellulase from Fusarium solani: purification and properties of the C1 component. Carbohydr Res 57: 117-133. https://doi.org/10.1016/s0008-6215(00)81925-4

Xia W, Xu XX, Qian LC, Shi PJ, Bai YG, Luo HY, Ma R, Yao B (2016) Engineering a highly active thermophilic β‑glucosidase to enhance its pH stability and saccharification performance. Biotechnol Biofuels 9:147. https://doi.org/10.1186/s13068-016-0560-8

Xie J, Zhao D, Zhao L, Pei J, Xiao W, Ding G, Wang Z (2015) Overexpression and characterization of a Ca²⁺ activated thermostable β-glucosidase with high ginsenoside Rb1 to ginsenoside 20(S)-Rg3 bioconversion productivity. J Ind Microbiol Biotechnol 42:839–850.https://doi.org/10.1007/s10295-015-1608-7

Vaidy M, Seeta R, Mishra C, Deshpande V, Rao M (1984) A rapid and simplified procedure for purification of a cellulase from Fusarium lini. Biotechnol Bioeng 26(1):41-45. https://doi.org/10.1002/bit.260260109

Villena MA, Iranzo JFú, Pérez AIB (2007) β-glucosidase activity in wine yeasts: application in enology. Enzym Microb Technol 40:420–425. http://doi.org/10.1016/j.enzmictec.2006.07.013

Zaldivar J, Nielsen J, Olsson L (2001) Fuel ethanol production from lignocellulose: a challenge for metabolic engineering and process integration. Appl Microbiol Biotechnol 56:17–34. https://doi.org/10.1007/s002530100624

Zhang M, Su R, Qi W, He Z (2010) Enhanced enzymatic hydrolysis of lignocellulose by optimizing enzyme complexes. Appl Biochem Biotechnol 160:1407–1414. https://doi.org/10.1007/s12010-009-8602-3

Zhang Z, Liu J, Lan J, Duan C, Ma Q, Feng J (2014) Predominance of Trichoderma and Penicillium in cellulolytic aerobic filamentous fungi from subtropical and tropical forests in China, and their use in finding highly efficient β-glucosidase. Biotechnol Biofuels 7: 107. https://doi.org/10.1186/1754-6834-7-107

Table 1. Summary of purification of b-glucosidases produced by F. chlamydosporum HML 278

Purification step Total activity Total protein Specific activity Purification fold Yield Purification fold

(U) (mg) (U/mg) (%)

Crude enzyme 115.2 282.0 0.4 100.0 1.0

Native Page 45.6 14.8 3.1 39.6 7.8

Gel filtration chromatographic

BG FG1 4.5 0.8 5.6 4.0 14.0

BG FG2 21.8 1.9 11.5 20.0 28.8

Table 2. Effect of various metal ions and inhibitors on HML278 b-glucosidase activity.

Metal ions and inhibitors Relative b-glucosidase activity (%)

10 mM BG FG1 BG FG2

Control (Crude) 100 100

Mn²⁺ 258.6 234.6

Mg²⁺ 186.4 176.4

Ca²⁺ 159.8 148.2

Zn²⁺ 102.4 98.8

Ni⁺ 92.6 96.2

Cu²⁺ 64.6. 54.5

Ag²⁺ 56.2 43.4

Co²^＋ 48.2 38.2

Hg²⁺ 40.8 30.2

Values represent the means of values from three independent experiments, with a standard deviation

Download PDF

Journal Publication

published 08 Oct, 2020

Read the published version in AMB Express →

Editorial decision: Major Revision
12 Aug, 2020
Review #2 received at journal
24 Jul, 2020
Review #1 received at journal
24 Jul, 2020
Review #3 received at journal
22 Jul, 2020
Reviewer #3 agreed at journal
12 Jul, 2020
Reviewer #2 agreed at journal
10 Jul, 2020
Reviewers invited by journal
09 Jul, 2020
Reviewer #1 agreed at journal
09 Jul, 2020
Editor assigned by journal
08 Jul, 2020
Editor invited by journal
07 Jul, 2020
Submission checks completed at journal
18 Jun, 2020
First submitted to journal
16 Jun, 2020

You are reading this older preprint version

Read the latest preprint version →

One-step purification and characterization of two novel Thermotolerant β-1,4-glucosidases from a newly isolated strain of Fusarium chlamydosporum HML278

Status:

Journal Publication

Version 1

Abstract

Figures

Key Points

Introduction

Materials And Methods

Results

Discussion

Declarations

References

Tables

Status:

Journal Publication

Version 1