For neonates, who are at particularly high risk for overdose infusion errors, smart pumps have the potential to be particularly valuable. However, this value is only realized when the pumps and libraries are tailored to use with neonates and the equipment and software are used as intended. Because medication administration errors are more likely to reach the patient, smart pumps have the potential to provide additional protection by double-checking nurse programming. The goal of our study was to assess whether smart pumps are able to prevent medication overdoses in continuous medications administered to the neonatal population. Overall, we found that nurses took advantage of the safety features of smart pumps and programmed the majority of infusions using the drug library with dose error reduction software. This high rate of compliance has been shown to be critical to the effective use of smart pumps. [8, 18, 19] Although our rate of compliance is higher than previously reported rates[12, 13], basic infusions, which lack the safety features of the DERS, were still used for 11-16% of infusions. Targeted discussions with frontline smart pump users revealed that our library had limited options for intravenous fluid selection that did not match the large variety of fluids being used. Work is underway to expand fluid options in our neonatal library, and our experience supports the need for regular reassessment to understand the reasons for basic infusion use in all institutions.
Along with the use of basic infusions, other workarounds that generated alerts were evident in our data. When evaluating hard stops, we found that nurses programmed the pump rate at 2-4 times the dose to facilitate rapid pump priming in 15-30 minutes instead of one hour. Discussion with the nurses revealed the need for efficiency in the face of urgent patient needs. Smart pumps are not perfect, and workarounds occur when there is a mismatch between the capabilities of a technology and demands of care. [20, 21] Our findings are consistent with the causes of workarounds identified by others, which include patient issues, the need for efficiency, technology-related issues, and organizational issues where policies or libraries do not align with clinical practice. [20-22]
Previous studies have used the number of infusions that are reprogrammed or cancelled to assess prevented errors. We found that there were many attempts to exceed the soft maximum limits, less frequent attempts to exceed the hard maximum limits, and that many infusions were cancelled or reprogrammed. Looking specifically at attempts to exceed hard maximums, which we used as a proxy for potentially prevented errors, we found that smart pumps identified and prevented significant overdoses of several high-risk medications, including narcotics, sedatives and insulin, demonstrating their utility in improving patient safety in the NICU. While some hard stops may be contributed to attempts at pump priming, we found examples of incorrect programmed doses, decimal point errors, confusion between two simultaneous medications, and attempts to bolus using the continuous infusion setting. Although these events were infrequent compared to the number of overall infusion starts, the possibility of delivering highly dangerous doses was prevented through the use of the dose error reduction software. This rate of potential error prevention by smart pumps is in line with that reported in other ICU environments. [23] For soft alerts, given that the typical response is to override the alert, cancelling or reprogramming of the infusion is more likely to represent a true prevented error. We found 2093 examples of cancelled or reprogrammed infusions after soft alerts.
The second goal of our study was to assess whether smart pumps are a source of alert burden and potential alert fatigue in the NICU. When looking across the unit as a whole, our data suggest that smart pump alerts for continuous infusions do not contribute significantly to overall alert burden with only 3-5% of infusions alerting per infusion start, which is significantly less than the 12-16 alarms/hour nurses experience from physiologic monitors in the NICU.[24, 25] While there was a statistically significant change in the percentage of alerts per year, it is unlikely that this represents a clinically significant change given the relatively low frequency of infusion-related alerts. When we evaluate alerts from the perspective of the patient, however, we found that alerts cluster around specific patients and specific infusions, with 17% of infusions generating significant alert numbers. In these unique and interesting situations, we found that a single medication in a single patient could repetitively alert, creating a very high alert burden and potentially making it difficult for a caregiver to identify and act upon appropriate alerts representing true errors. The evidence on alert fatigue shows that fatigue is connected to the proportion of repeated alerts[14], potentially creating unique situations where individual patients are placed at increased risk for experiencing missed alerts or delayed responses. In our data, repetitive alerts occurred during the initial start of medications and clustered around patients that required doses of medication that were significantly higher than normal, most commonly at the end of life, when sedatives and analgesics had been significantly escalated. There are patients that will be exceptions to the standards of the library based on their individual physiology or during end-of-life care. Current smart pumps do not have a way to account for these individual situations. While smart pumps may be working appropriately to raise awareness of a dose being given outside of the usual range, repeated alerts are a new source of alert fatigue at the patient level; this may decrease nurse sensitivity to the alert, placing the patient at especially high risk for a nurse to miss a true error. Future work should focus on ways to mitigate this issue, identifying ways to individualize smart pump performance.
Given the opportunity, the vast majority of nurses override alerts, calling into question the ability to appropriately recognize alerts that require attention. This parallels the observed phenomenon seen with medication alerts produced during the prescribing phase of the medication lifecycle.[26, 27] Of concern, many high-risk medications that have been associated with harmful errors are generating a high number of smart pump alerts. The medications responsible for a high alert burden have high individual alert rates per infusion starts, suggesting that their dosing rules may not be optimized. Additionally, soft minimum alerts, which have high override rates[22] and low potential to reduce harm, contributed significantly to the alert burden in our study. Ideally, the best alerts identify true errors and require action.
In looking at the amount that programmed doses exceed limits, we found that several medications that generated high alert rates, such as morphine, alerted for doses that were just 20% above the soft dosing limit. This may indicate that adjustment of the dosing limits in the drug library could significantly decrease alert burden while continuing to promote patient safety by alerting for more significant overdoses. Several authors have demonstrated the utility of small dosing limit adjustments to decrease the number of nonactionable alerts, but more evidence is needed to understand the effect of changing dosing limits on patient safety.[13, 28, 29]
Others have shown that alert number differs by time of day, day of the week, and month.[15] We found that overall alert number is highest on the evening shift but we contribute this to the fact that the majority of new fluids, TPN and lipids are hung during this shift. The overall percentage of alerts per infusion starts was not different based on shift or day of the week. Our data also suggest that nurses may experience some desensitization to infusion pump alerts over time. In desensitization, repeated exposure to alerts leads to declining responsiveness over time.[14, 30-32] We found a small but statistically significant increase in the number of alerts that were overridden and a decrease in the number of alerts that were reprogrammed or cancelled over time, suggesting that nurses may experience some densitization with continued infusion pump experience. No significant changes to the pump library limits or to hospital policy occurred during that time to otherwise account for the change. Given the small rate of change, further evaluation over time is required to determine if this is a true phenomenon.
Strengths/Limitations
Our study has a number of strengths. We took advantage of wirelessly downloaded smart pump information to build a large neonatal database evaluating over 370,000 infusions over multiple years. The granularity of this large dataset allowed us to identify unique trends in the data to understand some of the benefits and inherent risks of smart pumps. The current literature on medication administration errors in neonates is based primarily on small observational studies. This study is the first neonatal study to use non-observational methodology and a large dataset to assess the effect of smart pumps on neonatal safety.
There are limits to this approach as well. First, by utilizing a data approach, we lack the ability to assess human factors and contextual factors, such as patient and unit acuity, or workload complexity, which may influence the caregiver response to alerts and can affect how data is interpreted. While we met with frontline smart pump users to understand data trends and workarounds, we did not perform intensive observations or structured interviews. Second, there is not a one-to-one correlation between orders and infusions, which makes it impossible to ascertain the number of expected infusions to confirm complete data capture. Third, our study was limited to a single intensive care unit in a single site, which may limit generalizability to other environments and populations. Finally, we chose to focus on continuous medications, and the issues around dosing limits, alerts and alert fatigue may differ for intermittent medications compared to continuous medications.
Given the large number of infusions utilized in neonates, and essentially in all hospitalized patients, it is clear that measures that improve medication and fluid safety can have a significant impact. What appears to be a small number of prevented errors becomes large when analyzed at the level of the institution or hospital system. To further optimize the effectiveness of smart pumps, future work should evaluate the effect of smart pump alert burden on an individual caregiver level as individual alert fatigue or desensitization may contribute to medication errors.